Boeing and the US aviation authorities have come under increasing pressure to ground the 737 Max despite repeated reassurances as the European Union and numerous other countries halted flights and Donald Trump weighed in following a second fatal crash involving the plane in less than five months.US regulators, airlines and the manufacturer have become increasingly isolated in maintaining that the plane is safe.
On Wednesday, India’s aviation ministry said the planes would be grounded immediately and New Zealand suspended operation of the plane due to the “level of uncertainty” about the cause of the recent Ethiopian Airlines crash. Malaysia also temporarily banned the plane from their airspace, and Fiji Airways became the latest carrier to stop using the aircraft.
Norwegian Air said it expected compensation from Boeing for being forced to ground its planes, Reuters reported on Wednesday morning.
Daniel K Elwell, the acting administrator of the Federal Aviation Administration, said on Tuesday it “continues to review extensively all available data and aggregate safety performance from operators and pilots of the Boing 737 Max. Thus far, our review shows no systematic performance issues and provides no basis to order grounding the aircraft. Nor have other civil aviation authorities provided data to us that would warrant action.”
Boeing, meanwhile, reiterated its support for the 737 Max, saying it had “full confidence” in its safety.
However, the global reaction to Sunday’s fatal crash involving an Ethiopian Airlines 737 Max is adding pressure on the company and the Federal Aviation Administration to act.
At least 27 airlines have grounded the Max and more than half of the 350 aircraft in service have been withdrawn from use.
Pilots of at least two US flights have complained that their new Boeing jet pointed its nose down automatically.
Trump said on Tuesday that modern planes were “becoming far too complex to fly”.
The Association of Professional Flight Attendants called on American Airlines to ground its 737 Max fleet pending further investigation.
The EU’s aviation safety agency, EASA, suspended all flights by Boeing’s 737-8 and 737-9 models after the UK, Ireland, Germany, France and other countries made similar moves.
Explaining the UK’s decision to ban the planes, a spokesman for the British Civil Aviation Authority said: “As we do not currently have sufficient information from the flight data recorder we have, as a precautionary measure, issued instructions to stop any commercial passenger flights from any operator arriving, departing or overflying UK airspace.”
The British pilots’ union, Balpa, welcomed the decision, saying: “Safety must come first.”
Boeing said: “We understand that regulatory agencies and customers have made decisions that they believe are most appropriate for their home markets. We’ll continue to engage with them to ensure they have the information needed to have confidence in operating their fleets.”
Boeing plans to update the Max’s software and change flight controls and training guidelines.
There are five 737 Max aircraft registered and operational in the UK, all belonging to TUI. Norwegian has also grounded all its 18 737 Max 8 planes, registered across Europe, including several which it uses to operate transatlantic flights from Edinburgh and Ireland to the US.
Turkish Airlines also operates 737 Max 8 planes. Two of its flights bound for Britain appear to have been forced to turn back to Istanbul in midair, according to FlightRadar24.
TUI, the world’s largest travel and tourism company, said it would stop using the 737 Max across all six airlines in its group.
Earlier on Tuesday, Australia and Singapore suspended operations of all Boeing 737 Max aircraft in and out of their airports, after Indonesia and China grounded their fleets of the Max 8. Oman and South Korea have also followed suit.
Nearly 40% of the in-service fleet of 371 Max jets globally have been grounded, according to the industry publication Flightglobal, including 97 jets in the biggest market, China.
In the US, American Airlines and Southwest Airlines operate the Max 8, and United Airlines flies a slightly larger version, the Max 9. All three carriers vouched for the safety of Max aircraft on Wednesday.
Two US airline pilots filed voluntary safety reports last year to a database compiled by Nasa, saying an automated system seemed to cause their 737 Max planes to tilt down suddenly.
The pilots said that soon after engaging the autopilot on Max 8 planes, the nose tilted down sharply. In both cases, they recovered quickly after disconnecting the autopilot.
The problem did not appear related to the automated anti-stall system that is suspected of contributing to a deadly October crash in Indonesia.
The voluntary safety reports do not publicly reveal the names of pilots, the airlines or the location of the incidents. It was also unclear whether the accounts led to any actions by the FAA or the pilots’ airlines.
(May 22, 2017) Boeing 737 Max enters commercial service
The first Boeing 737 Max begins commercial operations with Malindo Air. Norwegian Air is also an early adopter of the new model, operating transatlantic flights. The model promises fuel efficiencies attractive to carriers.
(October 29, 2018) Lion Air crash
Lion Air flight JT610 crashes after making a sudden, sharp dive into the Java Sea 13 minutes after departing from Jakarta, Indonesia. All 189 people onboard are killed. That particular plane had been in use for less than three months. The plane's black box recorder reveals that the Lion Air plane had experienced problems with its airspeed indicators on its last four flights.
(November 7, 2018) Boeing's new advice
Boeing issues revised instructions on how pilots should react to erroneous readings from “angle of attack” sensors, believed to be a key factor in the Lion Air crash.
(March 10, 2019) Ethiopia Airlines crash
Flight ET302 crashes about six minutes after taking off from the Ethiopian capital, Addis Ababa, killing all 157 people onboard. The captain had reported difficulties, and flight radar data shows the aircraft was climbing erratically with an unstable vertical airspeed.
(March 13, 2019) Boeing grounds fleet
The EU, Canada and the US all ground the Boeing 737 Max. Boeing itself issues a statement saying it “continues to have full confidence in the safety of the 737 Max”, but that “out of an abundance of caution and in order to reassure the flying public” it w recommending the grounding of the entire global fleet of 371 aircraft.
(April 4, 2019) Interim report findings
The interim report into the Ethiopian Airlines crash finds that the pilots correctly followed Boeing’s emergency instructions, but were still unable to stop the plane’s nose repeatedly pointing down. The jet hit an airspeed of 500 knots (575mph), well above its operational limits, before cockpit data recordings stopped.
(June 27, 2019) A new potential risk
Airlines extend their ban on using the Boeing 737 Max after the US aviation regulator said it had identified a new potential risk with the plane.
(July 10, 2019) Airbus soars
In the wake of Boeing’s troubles, Airbus seems set to overtake it as the world's biggest planemaker. As Boeing reported 239 commercial plane deliveries in the first half of the year, a 37% fall, rival Airbus shipped 389 deliveries, up 28% on the same period last year.
(July 15, 2019) Name change rumours
Pictures emerge of a Boeing 737 Max due to be delivered to Ryanair with the name 737 Max replaced by 737-8200 on the nose.
(October 30, 2019) Sensor concerns ignored
During congressional hearings into Boeing’s handling of the crisis, lawmakers were shown internal records revealing that three years before the crashes an employee had expressed concern that an anti-stall flight system could be triggered by a single sensor.
(January 10, 2020)
The crisis deepens with the release of hundreds of internal messages between employees working on the 737 Max aircraft, which boasted of deceiving safety regulators and said the plane had been “designed by clowns”.
(February 19, 2020)
Boeing orders inspections of its entire fleet of grounded 737 Max planes after it found foreign object debris in the fuel tanks of some of the mothballed planes.
An Ethiopian Airlines passenger jet plunged to the ground shortly after takeoff on Sunday, killing all 157 people onboard. The same model was involved in the Lion Air crash off Indonesia that killed 189 people in October. No evidence has emerged to link the two incidents, but in both cases pilots reported problems with the plane and requested permission to make an emergency landing before losing contact with ground control.
The plane’s black box recorders, containing flight data and cockpit voice recordings, have been recovered and could potentially provide some indication of the causes within days, depending on their condition.
The scare has wiped billions of dollars off the market value of the world’s biggest plane-maker.
Boeing’s stock fell further on Tuesday as international regulators moved against the 737 Max, and is unlikely to have been boosted by Trump’s intervention on Twitter.
The president said manufacturers were “always seeking to go one unnecessary step further, when often old and simpler is far better. Split second decisions are needed, and the complexity creates danger. All of this for great cost yet very little gain.”
He added: “I don’t want Albert Einstein to be my pilot. I want great flying professionals that are allowed to easily and quickly take control of a plane!”
Following his tweet, Trump met Boeing’s chief executive, Dennis Muilenburg, in the first known conversation between them since the Ethiopian Airlines plane crash.
Airlines using the Max 8 have been inundated with questions from concerned passengers since Sunday’s crash, many demanding to know which type of aircraft they will be taking – and their right to cancel based on that.
“It’s not 100% clear, but if you were at the airport and there were other flights not on a Max, a customer is likely to be accommodated asking to switch to another flight even though it’s not clearly provided for in published rules,” said John Cox, the founder and chief executive of Safety Operating Systems.
The Association of Professional Flight Attendants president, Lori Bassani, said the Max should be grounded. “The safety of our crews and passengers is paramount. Our flight attendants will not be forced to fly if they feel unsafe,” she said.
On Monday, the FAA noted that external reports were drawing similarities between the crashes in Ethiopia and off Indonesia. It said the Boeing 737 Max 8 was airworthy but that it had demanded design changes to the aircraft by April.
The US transportation secretary, Elaine Chao, said regulators would not hesitate to act if they found a safety issue. Boeing’s top executive told employees on Monday he was confident in the safety of the 737 Max, its top-selling aircraft.
Industry analysts said some disruption was inevitable from airlines grounding their 737 Max 8s, even though most of those who have done so have a small number of the planes in operation compared with their overall fleet size.
The aviation consultant John Strickland said cancellations were likely, adding that while there could be more planes on standby in quieter midweek or off-season periods, an ongoing grounding would cause headaches for airlines awaiting deliveries of 737 Max planes from Boeing: “Ryanair, for example, is expecting 50 in the next few months.”
Reuters contributed to this report
